Biomedical subjects

Firoz D Antia

Publications and source records attributed to Firoz D Antia.

4 recordsLinked to original sources

PubMed2006

Development of a gradient elution preparative high performance liquid chromatography method for the recovery of the antibiotic ertapenem from crystallization process streams.

A gradient elution preparative chromatography method was developed for the recovery of the antibiotic ertapenem from crystallization mother-liquor streams. The preparative HPLC method that was developed on the lab-scale employs an analytical size column of conventional dimensions (25 cm x 0.46 cm) packed with Kromasil C8 stationary phase. Gradient elution was used with aqueous acetic acid and acetonitrile as mobile phases. A target of processing approximately 30 mg of ertapenem per half an hour at a flow rate of 1.5 mL/min with high yield and adequate rejection of all major impurities was achieved. This corresponds to a productivity of approximately 0.6 kg ertapenem as free acid per kilogram of stationary phase per day (kkd). The scalability of the method was demonstrated by using a 5 cm i.d. column configuration to generate 10 g of purified ertapenem. This work complements a previous study improving on the productivity and throughput of the method by employing gradient elution and the use of crystallization to remove some key impurities that are chromatographically difficult to resolve [A. Vailaya, P. Sajonz, O. Sudah, V. Capodanno, R. Helmy, F.D. Antia, J. Chromatogr. A 1079 (2005) 80].

Chromatography, High Pressure Liquid↗

PubMed2005

Influence of mobile phase composition and thermodynamics on the normal phase chromatography of echinocandins.

In the normal phase preparative HPLC of fermentation derived echinocandins, resolution of key impurities from the product of interest, pneumocandin B(o), is accomplished using a ternary ethyl acetate/methanol/water mobile phase with silica gel as the sorbent. In this work, previous characterization of the system is extended to define the impact and role of water content on the separation efficiency and retention of pneumocandin B(o). Experimental results indicate that column efficiency, measured using both the product of interest and small molecule tracers (compounds used for pulse tests), is good despite the use of an irregular silica and unusually high levels (greater than 6%) of water in the mobile phase. In contrast to column efficiency measurements using small molecules (MEK and toluene), measurements performed with the product itself indicate improved efficiency with increasing water content of the mobile phase. Building on these results, a scale-up/scale-down protocol was developed based on measurements of column efficiency using theoretical plate counts determined with pneumocandin B(o). Since the solubility of pneumocandin B(o) in the ternary mobile phase is relatively low, a higher strength solvent with higher levels of methanol and water is employed for dissolution of the crude product at concentrations of up to 40g/L. The mismatch between the high strength solvent used for the feed introduction and the mobile phase has the potential to affect column performance. The impact of this mismatch using plate count measurements with the product at both analytical and semi-preparative scales was found not to be significant. Finally, a van't Hoff analysis was performed to characterize the thermodynamics of adsorption of pneumocandin B(o) on silica. The analysis shows that the adsorption process for pneumocandin B(o) on silica in the ternary solvent system is endothermic (DeltaH(ads)>0), implying that the adsorption is entropically driven. Results from an overall water balance across the column indicate significant enrichment of adsorbed water on the silica surface. These results further emphasize the importance of selective partitioning of water between the bulk mobile phase and the silica as a dominant factor in controlling retention.

Adsorption↗

PubMed2005

Exploiting pH mismatch in preparative high-performance liquid chromatographic recovery of ertapenem from mother liquor streams.

Preparative chromatography was successfully employed to recover ertapenem from mother liquor streams. The recovery process involved concentration of mother liquor stream by evaporation, purification by reversed-phase preparative high-performance liquid chromatography (HPLC), and removal of chromatographic solvents in the recovered fractions by evaporation. HPLC feed was prepared by stripping off the organic solvents from the mother liquor using a wiped-film evaporator. Purification was first carried out on a 25 cm x 0.46 cm analytical column packed with 10-microm Kromasil C8 particles and then scaled up to a 25 cm x 5 cm preparative column. Gram-level recovery of ertapenem with high purity was achieved by exploiting a novel approach based on pH mismatch between the feed and the eluent. Purified ertapenem streams from preparative HPLC runs were combined, evaporated and recycled into the crystallizer for ertapenem isolation.

Anti-Bacterial Agents↗

PubMedDate not supplied

Normal phase high-performance liquid chromatography of pneumocandins: in situ modification of silica with L-proline to separate structural analogues.

Lipopeptides such as pneumocandin B(0) are often produced by fermentation processes. Many compounds with similar structures (structural analogues), and hence similar physiochemical properties, are coproduced in the fermentation. We employed high performance liquid chromatography using silica gel as the stationary phase and a ternary ethyl acetate/MeOH/water mobile phase to separate pneumocandin B(0) from these structural analogues. Despite extensive efforts to optimize this system, two key structural analogues, pneumocandin E(0) and pneumocandin B(5), continued to be poorly resolved from the main product peak (pneumocandin B(0)). As a result, feed load was restricted and productivity was limited. In situ modification of the silica gel stationary phase with l-proline or other amino acids significantly enhances the resolution of the two key structural analogues from the compound of interest, enabling a two-fold increase in productivity. Results of a systematic study showed that the amine group in l-proline and other amino acids plays a key role in the modification of the surface of the silica gel to mediate the selectivity enhancement.

Chromatography, High Pressure Liquid↗