Biomedical subjects

Jean-Philippe Obert

Publications and source records attributed to Jean-Philippe Obert.

2 recordsLinked to original sources

PubMed2007

Investigation of drying stresses on proteins during lyophilization: differentiation between primary and secondary-drying stresses on lactate dehydrogenase using a humidity controlled mini freeze-dryer.

This article describes the design, performance testing, and application of a controlled humidity mini-freeze-dryer in studying the physical stability of lactate dehydrogenase during lyophilization. Performance evaluation of the mini-freeze-dryer was conducted with tests, namely water sublimation, radiation heat exchange, lowest achievable temperature, and leak testing. Protein stability studies were conducted by comparing protein activity at various stages of lyophilization with the initial activity. The shelf and condenser temperature were stable at <-40 degrees C, wall temperature was within 2 degrees C of the shelf temperature, and the leak rate was small. The chamber pressure was controlled by the ice on the condenser and the product temperature during sublimation was equal to the shelf temperature. Addition of Tween 80 prevented activity loss in solution and after freeze-thaw. No activity loss was observed after primary-drying even in absence of lyoprotectants and with collapse of cake structure. Five percent (w/w) sucrose concentration was required to achieve full stabilization. In conclusion, performance testing established that the mini-freeze-dryer was suitable for mechanistic freeze-drying studies. Secondary-drying was the critical step for protein stability. The concentration of sucrose required to stabilize the protein completely was several orders of magnitude higher than that required to satisfy the direct interaction requirement of the protein.

Animals↗

PubMed2004

New drying process for lactic bacteria based on their dehydration behavior in liquid medium.

This study describes the different stages of optimization in an original drying process for lactic acid bacteria that allows the retrieval of dried samples of Lactobacillus plantarum with maximum viability. The process involves the addition of casein powder to bacterial pellets, followed by mixing and then air-drying in a fluidized bed dryer. The effects on bacterial viability of the a(w) of the casein powder and the kinetics of a(w) variation in the fluidized bed dryer are considered. These parameters were first studied in a water-glycerol solution and the results were then applied to the drying process. Data from the study in liquid medium were reliable in the fluidized drying stage, insofar as optimal viability was achieved for similar dehydration times (16-50 min in liquid medium, and 30 min in the fluidized bed dryer). However, when the powder was mixed rapidly with bacteria, the level of destruction differed from that observed in liquid medium. Viability was up to 70% when the a(w) of water-glycerol was 0.55, whereas it was only 2.1% when the a(w) of the casein-bacterial mix was 0.64. The predictive capacity of dehydration in liquid medium is discussed with regard to the permeability of cells to external solutes. The new process allowed 100% survival of L. plantarum after complete drying (final a(w) < 0.2). However, when used for the desiccation of L. bulgaricus, these parameters achieved a viability of less than 10%.

Dehydration↗