L Madzingaidzo | PubMed Health

PubMed2002

Process development and optimisation of lactic acid purification using electrodialysis.

Cell free sodium lactate solutions were subjected to purification based on mono- and bi-polar electrodialysis. Lactate concentration in the product stream increased to a maximum of 15% during mono-polar electrodialysis. Stack energy consumption averaged 0.6 kW h kg(-1) lactate transported at current efficiencies in the 90% range. Under optimum feed concentration (125 g l(-1)) and process conditions (auto-current mode with conductivity setpoints of minimum 5 and maximum 40 mS cm(-1)), lactate flux reached 300 g m(-2) h(-1) and water flux were low for mono-polar electrodialysis averaging 0.3 kg H(2)O per M lactate transported. Glucose in the concentrate stream solutions was reduced to < 2 g l(-1). Acetate impurities enriched from about 0.5 g l(-1) in the feed stream to 1.5 g l(-1) in the concentrate stream solutions. After mono-polar electrodialysis, the concentrated sodium lactate solutions were further purified using bi-polar electrodialysis. Water transport during bi-polar electrodialysis reached figures of 0.070 - 0.222 kg H(2)O per M lactate. Free lactic acid concentration reached 16% with lactate flux of up to 300 g m(-2) h(-1). Stack energy consumption ranged from 0.6 to 1 kW h per kg lactate. Under optimised process conditions current efficiency during bi-polar electrodialysis was consistently around 90%. Glucose was further reduced from 2 to <1 g l(-1) in the free lactic acid solution. Acetic acid impurity remained at around 1 g l(-1). Significant reduction in colour and minerals in the product streams was observed during electrodialysis purification.

Bioreactors↗

PubMed2002

Thermophilic production of lactic acid using integrated membrane bioreactor systems coupled with monopolar electrodialysis.

The thermophilic Bacillus strain BS119 was selected for this study to demonstrate the long term performance of lactic acid production and simultaneous pre-purification. Integrated continuous cell recycle cultivation using ultra-filtration membrane bioreactor (MBR) systems was investigated. The permeate from the MBR was routed to an on-line electrodialysis (ED) to recover, pre-purify and concentrate lactate. The cultivation and ED was operated at 60 degrees C for more than 1,000 h at a pH of 6.5. At lower dilution rate (0.02 h(-1)), lactate concentration reached a maximum of 55 g l(-1) with clearly lower residual glucose levels. At 0.04 h(-1), lactate concentration was significantly lower at 35 g l(-1). Maximal volumetric productivities of 1.38 g l(-1) h(-1) were achieved. Under stable conditions, lactic acid yield on consumed glucose appeared stable at around 80%. It could be demonstrated that the addition of supplements like yeast extract and peptone severely influences product formation. Integration of mono-polar ED with the MBR systems yields lactate solutions with concentrations of up to 115 g l(-1). Because of the low substrate feed concentrations (less than 50 g l(-1)), lactate flux was rather poor, reaching a low maximum of 140 g m(-2) h(-1); nevertheless, stack energy consumption was positive with an average of 0.49 kWh kg(-1) lactate.

Bacillus↗