Biomedical subjects

M Plapp

Publications and source records attributed to M Plapp.

6 recordsLinked to original sources

PubMed2003

Towards a quantitative phase-field model of two-phase solidification.

We construct a diffuse-interface model of two-phase solidification that quantitatively reproduces the classic free boundary problem on solid-liquid interfaces in the thin-interface limit. Convergence tests and comparisons with boundary integral simulations of eutectic growth show good accuracy for steady-state lamellae, but the results for limit cycles depend on the interface thickness through the trijunction behavior. This raises the fundamental issue of diffuse multiple-junction dynamics.

Journal Article↗

PubMed2002

Pattern stability and trijunction motion in eutectic solidification.

We demonstrate by both experiments and phase-field simulations that lamellar eutectic growth can be stable for a wide range of spacings below the point of minimum undercooling at low velocity, contrary to what is predicted by existing stability analyses. This overstabilization can be explained by relaxing Cahn's assumption that lamellae grow locally normal to the eutectic interface.

Journal Article↗

PubMed2001

Phase-field modeling of microstructural pattern formation during directional solidification of peritectic alloys without morphological instability.

During the directional solidification of peritectic alloys, two stable solid phases (parent and peritectic) grow competitively into a metastable liquid phase of larger impurity content than either solid phase. When the parent or both solid phases are morphologically unstable, i.e., for a small temperature gradient/growth rate ratio (G/v(p)), one solid phase usually outgrows and covers the other phase, leading to a cellular-dendritic array structure closely analogous to the one formed during monophase solidification of a dilute binary alloy. In contrast, when G/v(p) is large enough for both phases to be morphologically stable, the formation of the microstructure becomes controlled by a subtle interplay between the nucleation and growth of the two solid phases. The structures that have been observed in this regime (in small samples where convection effects are suppressed) include alternate layers (bands) of the parent and peritectic phases perpendicular to the growth direction, which are formed by alternate nucleation and lateral spreading of one phase onto the other as proposed in a recent model [R. Trivedi, Metall. Mater. Trans. A 26, 1 (1995)], as well as partially filled bands (islands), where the peritectic phase does not fully cover the parent phase which grows continuously. We develop a phase-field model of peritectic solidification that incorporates nucleation processes in order to explore the formation of these structures. Simulations of this model shed light on the morphology transition from islands to bands, the dynamics of spreading of the peritectic phase on the parent phase following nucleation, which turns out to be characterized by a remarkably constant acceleration, and the types of growth morphology that one might expect to observe in large samples under purely diffusive growth conditions.

Journal Article↗

PubMed2000

Multiscale random-walk algorithm for simulating interfacial pattern formation.

We present a novel computational method to simulate accurately a wide range of interfacial patterns whose growth is limited by a large-scale diffusion field. To illustrate the computational power of this method, we demonstrate that it can be used to simulate three-dimensional dendritic growth in a previously unreachable range of low undercoolings that is of direct experimental relevance.

Algorithms↗

PubMed2000

Three-dimensional dendrite-tip morphology at low undercooling

We investigate the three-dimensional morphology of the dendrite tip using the phase-field method. We find that, for low undercoolings, this morphology is ostensibly independent of anisotropy strength except for a localized shape distortion near the tip that only affects the value of the tip radius rho [which is crudely approximated by rho approximately (1-alpha)rho(Iv) where rho(Iv) is the Ivantsov tip radius of an isothermal paraboloid with the same tip velocity and alpha is the stiffness anisotropy]. The universal tip shape, which excludes this distortion, is well fitted by the form z=-r(2)/2+A(4)r(4) cos 4straight phi where |z| is the distance from the tip and all lengths are scaled by rho(Iv). This fit yields A4 in the range 0.004-0.005 in good quantitative agreement with the existing tip morphology measurements in succinonitrile [LaCombe et al., Phys. Rev. E 52, 2778 (1995)], which are reanalyzed here and found to be consistent with a single cos 4straight phi mode nonaxisymmetric deviation from a paraboloid. Moreover, the fin shape away from the tip is well fitted by the power law z=-a|x|(5/3) with a approximately 0.68. Finally, the characterization of the operating state of the dendrite tip is revisited in the light of these results.

Journal Article↗

PubMed1999

Eutectic colony formation: a stability analysis.

Experiments have widely shown that a steady-state lamellar eutectic solidification front is destabilized on a scale much larger than the lamellar spacing by the rejection of a dilute ternary impurity and forms two-phase cells commonly referred to as "eutectic colonies." We extend the stability analysis of Datye and Langer [V. Datye and J. S. Langer, Phys. Rev. B 24, 4155 (1981)] for a binary eutectic to include the effect of a ternary impurity. We find that the expressions for the critical onset velocity and morphological instability wavelength are analogous to those for the classic Mullins-Sekerka instability of a monophase planar interface, albeit with an effective surface tension that depends on the geometry of the lamellar interface and, nontrivially, on interlamellar diffusion. A qualitatively new aspect of this instability is the occurrence of oscillatory modes due to the interplay between the destabilizing effect of the ternary impurity and the dynamical feedback of the local change in lamellar spacing on the front motion. In a transient regime, these modes lead to the formation of large scale oscillatory microstructures for which there is recent experimental evidence in a transparent organic system. Moreover, it is shown that the eutectic front dynamics on a scale larger than the lamellar spacing can be formulated as an effective monophase interface free boundary problem with a modified Gibbs-Thomson condition that is coupled to a slow evolution equation for the lamellar spacing. This formulation provides additional physical insights into the nature of the instability and a simple means to calculate an approximate stability spectrum. Finally, we investigate the influence of the ternary impurity on a short wavelength oscillatory instability that is already present at off-eutectic compositions in binary eutectics.

Journal Article↗