[Microwave extraction technique].

Y Bu; Z Guo

Home/Archive/PubMed

PubMed · 15739331

[Microwave extraction technique].

Y Bu·Z Guo

View original source ↗Export metadata ↓

Abstract

A new microwave aided extraction (MAE) technique is introduced in this paper. It gives the extraction method as well as reagents, equipment and conditions used in the technique. In temperature controlled pressurized vessels, polar solvent (eg. acetone) and the combinations of polar and non-polar solvents can be heated to approximately 100 degrees C above their normal boiling points. It is told that the higher the extraction temperature the more the recovery is. The ratio of polar to non-polar solvents affects not only the microwave heating rate but also the extraction recovery. The highest recovery ratios are gotten at the solvent ratio of three parts of acetone to two parts of hexane. We can see from the pesticides chromatogram with MAE, that very little break-down of endrin or DDT are detected and they are well below the EPA specified tolerance limits. We can find from the comparison of MAE with sonication and Soxhlet extraction techniques that microwave extraction technique has not only higher average recoveries (%) but also good precision (RSD, %). The data and comparison results illustrate that the microwave extraction is a rapid method (about 15 minutes) with less solvent consumption (about 30-50 mL), good recovery, and easy to be controlled automatically in comparison with the Soxhlet extraction, sonication and other extraction methods.

Explore related subjects

Chemical Fractionation Hexanes Microwaves Pesticides Solvents Temperature Evaluation Study Journal Article Research Support, Non-U.S. Gov't

Keep this discovery

Explore connections, maps & timelines

BibTeX RIS

Y Bu, Z Guo. 1997. [Microwave extraction technique].. https://pubmed.ncbi.nlm.nih.gov/15739331/

Cite the original work for its findings. Save a collection to share your selection of sources.

KEEP EXPLORING

Related citations

PubMed2007

Improved procedure for separation and purification of Arthronema africanum phycobiliproteins.

A rapid, inexpensive and reliable procedure for separation and purification of C-phycocyanin (C-PC) and allophycocyanin (APC) from Arthronema africanum based on a previously described rivanol-sulfate method for C-PC purification was developed. Exclusion of NaCl from the extraction buffer resulted in complete separation of APC and C-PC, two-fold reduction of rivanol treatments, and a higher yield and purity of C-PC. Pure C-PC (A(620)/A(280) of 4.52) and APC (A(652)/A(280) of 2.41) were obtained. The estimated molecular masses of the alpha and beta subunits were 17 and 19 kDsmall a, Cyrillic for capital ES, Cyrillic-phycocyanin and 16 and 18 kDsmall a, Cyrillic for APC, respectively. The overall C-PC recovery of 55% (w/w) from its content (100 mg) in the crude extract was 10-20% higher than so far reported. The procedure appears promising for scaling up and broader applications.

Chemical Fractionation↗

PubMed2007

Separation of genomic DNA, RNA, and open circular plasmid DNA from supercoiled plasmid DNA by combining denaturation, selective renaturation and aqueous two-phase extraction.

In the current study we developed a process for the capture of pDNA exploiting the ability of aqueous two-phase systems to differentiate between different forms of DNA. In these systems scpDNA exhibits a near quantitative partitioning in the salt-rich bottom phase. The successive recovery from the salt rich bottom phase is accomplished by a novel membrane step. The polish operation to meet final purity demands is again based on a system exploiting a combination of the denaturation of the nucleic acids present, specific renaturation of scpDNA, and an ATP system able to differentiate between the renatured scpDNA and the denatured contaminants such as ocpDNA and genomic host DNA. This polish step thus allows a rapid and efficient separation of scpDNA from contaminating nucleic acids which up to date otherwise only can be accomplished with much more cumbersome chromatographic methods. In a benchmark comparison, it could be shown that the newly developed process exhibits a comparable yield to an industrial standard process while at the same time showing superior performance in terms of purity and process time. Additionally it could be shown that the developed polish procedure can be applied as a standalone module to support already existing processes.

Chemical Fractionation↗

PubMed2007

Effect of solvent concentration on the extraction kinetics and diffusivity of Cyclosporin A in the fungus Tolypocladium inflatum.

The kinetics of solid-liquid extraction and extraction yields of the immunosuppressant drug Cyclosporin A (CyA) from the mycelia of Tolypocladium inflatum were examined in this study. A 2 L stirred, baffled vessel was used to extract CyA from wet mycelia mass. Three different organic solvents were used, namely, methanol, acetone, and isopropanol at different concentrations in aqueous mixtures at room temperature. It was found that the best solvent was acetone at 50% v/v concentration achieving 100% extraction of CyA from the mycelia of T. inflatum. Although acetone proved to be the better solvent for CyA extraction, further studies were performed using methanol. A linear relationship was found between extraction yield of CyA and methanol concentration with 100% CyA extraction at 90% v/v methanol. The partition coefficients of CyA between the solid mycelia phase and the aqueous solvent phase were found to decrease exponentially with increasing methanol concentration. A liquid extraction model was developed based on the diffusion equation to correlate the kinetic data of CyA extraction from the solid mycelia of T. inflatum. Non-linear regression analysis of experimental data was used with the diffusion equation in order to calculate the effective diffusivities of CyA in the mycelia of T. inflatum. For all three organic solvents used, the effective diffusivities of CyA were found to be between 4.41 x 10(-15) and 6.18 x 10(-14) m(2)/s. This is the first time CyA effective diffusivities in T. inflatum are reported in the literature.

Chemical Fractionation↗