Biomedical subjects

W M Ingledew

Publications and source records attributed to W M Ingledew.

At least 37 records · Page 2Linked to original sources

PubMed1990

Fuel alcohol production: effects of free amino nitrogen on fermentation of very-high-gravity wheat mashes.

Although wheat mashes contain only growth-limiting amounts of free amino nitrogen, fermentations by active dry yeast (Saccharomyces cerevisiae) were completed (all fermentable sugars consumed) in 8 days at 20 degrees C even when the mash contained 35 g of dissolved solids per 100 ml. Supplementing wheat mashes with yeast extract, Casamino Acids, or a single amino acid such as glutamic acid stimulated growth of the yeast and reduced the fermentation time. With 0.9% yeast extract as the supplement, the fermentation time was reduced from 8 to 3 days, and a final ethanol yield of 17.1% (vol/vol) was achieved. Free amino nitrogen derived in situ through the hydrolysis of wheat proteins by a protease could substitute for the exogenous nitrogen source. Studies indicated, however, that exogenously added glycine (although readily taken up by the yeast) reduced the cell yield and prolonged the fermentation time. The results suggested that there are qualitative differences among amino acids with regard to their suitability to serve as nitrogen sources for the growth of yeast. The complete utilization of carbohydrates in wheat mashes containing very little free amino nitrogen presumably resulted because they had the "right" kind of amino acids.

Ethanol↗

PubMed1989

Effect of yeast hulls on stuck and sluggish wine fermentations: importance of the lipid component.

The effect of yeast hulls (yeast ghosts) on sluggish or stuck white wine fermentations was studied. The enhancing effect on yeast growth and fermentation rate displayed by the hulls was shown to be similar to the effect provided by lipid extract from the same hulls. Unsaturated fatty acids and sterols were incorporated into the yeast from lipid extracts during fermentation carried out under oxygen-limited conditions. Adsorption of toxic medium-chain fatty acid (decanoic acid) onto the yeast hulls took place through a dialysis membrane. However, when the hulls were placed inside a dialysis bag, the increase in yeast growth and fermentation rate seen when freely suspended hulls were used did not occur. Accordingly, the effect of yeast hulls in preventing stuck fermentations cannot be attributed only to the adsorption and consequent removal of medium-chain fatty acids from the juice.

Journal Article↗

PubMed1988

The acetone-butanol-ethanol fermentation.

Renewed interest in the acetone-butanol-ethanol (ABE) fermentation as a route for industrial production of butanol has been evident since the oil crisis of the 1970s. The present review includes an historical recap of the traditional industrial process and culturing practices useful in maintaining viable solvent-producing cultures, and then summarizes new and exciting research on the physiology and genetics of the microorganisms as well as process design. Most of these reports relate to improvements in solvent yield and the overall process, since traditional production is not efficient under present economic conditions. Conclusions are then made on future developments necessary for the establishment of an economically viable industrial process.

Acetone↗

PubMed1986

Ethanol tolerance in yeasts.

It is now certain that the inherent ethanol tolerance of the Saccharomyces strain used is not the prime factor regulating the level of ethanol that can be produced in a high sugar brewing, wine, sake, or distillery fermentation. In fact, in terms of the maximum concentration that these yeasts can produce under batch (16 to 17% [v/v]) or fed-batch conditions, there is clearly no difference in ethanol tolerance. This is not to say, however, that under defined conditions there is no difference in ethanol tolerance among different Saccharomyces yeasts. This property, although a genetic determinant, is clearly influenced by many factors (carbohydrate level, wort nutrition, temperature, osmotic pressure/water activity, and substrate concentration), and each yeast strain reacts to each factor differently. This will indeed lead to differences in measured tolerance. Thus, it is extremely important that each of these be taken into consideration when determining "tolerance" for a particular set of fermentation conditions. The manner in which each alcohol-related industry has evolved is now known to have played a major role in determining traditional thinking on ethanol tolerance in Saccharomyces yeasts. It is interesting to speculate on how different our thinking on ethanol tolerance would be today if sake fermentations had not evolved with successive mashing and simultaneous saccharification and fermentation of rice carbohydrate, if distillers' worts were clarified prior to fermentation but brewers' wort were not, and if grape skins with their associated unsaturated lipids had not been an integral part of red wine musts. The time is now ripe for ethanol-related industries to take advantage of these findings to improve the economies of production. In the authors' opinion, breweries could produce higher alcohol beers if oxygenation (leading to unsaturated lipids) and "usable" nitrogen source levels were increased in high gravity worts. White wine fermentations could also, if desired, match the higher ethanol levels in red wines if oxygenation (to provide the unsaturated lipids deleted in part by the removal of the grape skins) were practiced and if care were given to assimilable nitrogen concentrations. This would hold true even at 10 to 14 degrees C, and the more rapid fermentations would maximize utilization of winery tankage.(ABSTRACT TRUNCATED AT 400 WORDS)

Ethanol↗

PubMed1984

High-gravity brewing: effects of nutrition on yeast composition, fermentative ability, and alcohol production.

A number of economic and product quality advantages exist in brewing when high-gravity worts of 16 to 18% dissolved solids are fermented. Above this level, production problems such as slow or stuck fermentations and poor yeast viability occur. Ethanol toxicity has been cited as the main cause, as brewers' yeasts are reported to tolerate only 7 to 9% (vol/vol) ethanol. The inhibitory effect of high osmotic pressure has also been implicated. In this report, it is demonstrated that the factor limiting the production of high levels of ethanol by brewing yeasts is actually a nutritional deficiency. When a nitrogen source, ergosterol, and oleic acid are added to worts up to 31% dissolved solids, it is possible to produce beers up to 16.2% (vol/vol) ethanol. Yeast viability remains high, and the yeasts can be repitched at least five times. Supplementation does not increase the fermentative tolerance of the yeasts to ethanol but increases the length and level of new yeast cell mass synthesis over that seen in unsupplemented wort (and therefore the period of more rapid wort attenuation). Glycogen, protein, and sterol levels in yeasts were examined, as was the importance of pitching rate, temperature, and degree of anaerobiosis. The ethanol tolerance of brewers' yeast is suggested to be no different than that of sake or distillers' yeast.

Journal Article↗

PubMed1982

Isolation and characterization of Schwanniomyces alluvius amylolytic enzymes.

The extracellular amylolytic enzymes of Schwanniomyces alluvius were studied to determine future optimization of this yeast for the production of industrial ethanol from starch. Both alpha-amylase and glucoamylase were isolated and purified. alpha-Amylase had an optimum pH of 6.3 and was stable from pH 4.5 to 7.5. The optimum temperature for the enzyme was 40 degrees C, but it was quickly inactivated at temperatures above 40 degrees C. The Km for soluble starch was 0.364 mg/ml. The molecular weight was calculated to be 61,900 +/- 700. alpha-Amylase was capable of releasing glucose from starch, but not from pullulan. Glucoamylase had an optimum pH of 5.0 and was stable from pH 4.0 to greater than 8.0. The optimum temperature for the enzyme was 50 degrees C, and although less heat sensitive than alpha-amylase, it was quickly inactivated at 60 degrees C. Km values were 12.67 mg/ml for soluble starch and 0.72 mM for maltose. The molecular weight was calculated to be 155,000 +/- 3,000. Glucoamylase released only glucose from both soluble starch and pullulan. S. alluvius is one of the very few yeasts to possess both alpha-amylase and glucoamylase as well as some fermentative capacity to produce ethanol.

Amylases↗

PubMed1982

Improved method for detection of starch hydrolysis.

A new starch hydrolysis detection method which does not rely on iodine staining or the use of color-complexed starch is described. A linear relationship was obtained with agar-starch plates when net clearing zones around colonies of yeasts were plotted against enzyme levels (semilogarithm scale) produced by the same yeast strains in liquid medium. A similar relationship between starch clearing zones and alpha-amylase levels from three different sources was observed. These observations suggest that the method is useful in mutant isolations, strain improvement programs, and the prediction of alpha-amylase activities in culture filtrates or column effluents.

Journal Article↗

PubMed1976

Use of the Hungate anaerobic technique in the isolation of phloroglucinol-negative mutants of Coprococcus species.

The Hungate anaerobic technique was used with a standard procedure for bacterial mutagenesis employing N-methyl-N-nitro-N'-nitrosoguanidine to obtain mutants of an obligate anaerobe. Three mutant strains were derived from a Coprococcus sp., strain Pe15, a rumen anaerobe capable of growing on phloroglucinol. The mutants did not grow on phloroglucinol but did degrade the compound in anaerobic washed-cell suspensions, producing the same end products in approximately the same proportions as the wild type. It was concluded that the mutants were blocked in a unique step or steps necessary for carbon skeleton or energy synthesis from phloroglucinol and not in formation of an enzyme involved in the pathway of phloroglucinol degradation.

Anaerobiosis↗

PubMed1976

Products of anaerobic phloroglucinol degradation by Coprococcus sp. Pe15.

Under anaerobic conditions, resting cell suspensions of Coprococcus sp. Pe15 degraded 1 molecule of phloroglucinol to 2 molecules of acetic acid and 2 molecules of carbon dioxide. The organism metabolized the flavonoids rhamnetin and quercetin anaerobically in 20% rumen fluid medium but failed to grow under similar conditions at the expense of any of 39 other aromatic or flavonoid compounds tested.

Acetates↗

PubMed1976

Potash guar gum--a source of halophilic bacteria.

Moderate and extreme halophilic microorganisms have been isolated from guar gum solutions dissolved in potash brine for use in sylvite froth flotation. Tentative identifications have been made of vibrio, Halobacterium, and Halococcus species. Reinoculation of these isolates into guar gum solutions has shown that they are not carbohydrate-utilizing strains, but instead metabolize the contaminating proteins present in guar.

Halobacteriaceae↗

PubMed1975

The relationship of acid-soluble glycogen to yeast flocculation.

A relationship between yeast flocculation and intracellular acid-soluble glycogen has been established which has been substantiated using flocculation mutants (mutants with altered capacities to flocculate) as well as a normal strain of Saccharomyces carlsbergensis. Sound evidence exists to implicate physiological differences in carbohydrate metabolism (glycogen storage) to this physical property of brewing significance.

Acids↗

PubMed1975

Glycogen--a physiological determinant of yeast flocculation?

Evidence is provided to extend earlier observations that glycogen and flocculence levels vary concurrently in brewing yeast. The use of glycogen mutants, the alterations of growth conditions specifically to inhibit glycogen storage, and observations on glycogen decreases during endogenous metabolism have verified the above. A mechanism by which glycogen might exert its effect on flocculation is suggested.

Acids↗

PubMed1973

Trends in wort carbohydrate utilization.

A gas chromatographic method suitable for any type of low-molecular-weight carbohydrate analysis has been utilized to determine the individual wort sugars in corn adjunct wort from a Western Canadian brewery. The fluctuations in each sugar during primary lager fermentation have been graphed. "End fermented" wort has been shown to contain some maltotriose, a small amount of maltose, and the nonfermentable carbohydrates, including maltotetraose, maltopentose, and dextrins.

Journal Article↗

PubMed1972